Mgb Floor Pan Replacement

We carry a wide selection of mgb floor pans rocker panels and trunk extensions.

Mgb floor pan replacement.

Rust is from inside out. If the rust is severe especially around the rear spring hanger area and the foot wells then often replacing the floor pan is the best option. Jack austin steve lyle paul gaylo peter plouf and others. Needed something to do this week end so decided to toss a set of floors in the 1966 mgb.

Mgb roadsters can be less than waterproof and as a consequence can suffer from rust in the floor pan area where water has penetrated. Got a 77 b with rust in the front center section drivers side floor pan. This would effectively remove the heavy mig welded seam between floor and castle section. This leaves a 1 strip everywhere that the floor was spotwleded to the frame.

Some might say i did a hac. Removing the floors on an mgb by jonathan lipkin with help from. Normally i use a spotweld cutter to remove the strips. Classic 2 current fabrication is a trusted manufacturer of hard to find mg mgb rust repair panels and replacement auto body panels.

Both oe and reproduction floor pans are available for the mgb from moss. Ie sat in the desert az with tin for a top for a number of years. Even the section i took out wa. These welds run along the castle rails a flange about 1 wide that runs.

B remove and replace a 5 to 7cm strip of the floor pan adjacent to the inner sill step. Breathe new life into your mg m. Originals are a bit crusty. This time i decided to use the air chisel.

Quick mgb floorpan replacement. The floors on mgbs are made from sheet metal and secured to the castle rails and crossmembers by a series of spot welds. The oem replacement pans 458 885 458 875 one per side have the nuts for the seats and the studs for the brake and fuel line clamps already welded in place. Cheap car floor pan fix solid overview how to.

Cut all the bad metal out and i have 3 to 6 of good metal all the way around.